View IFC165PQ40_4464422.PDF datasheet online --- IC-ON-LINE

Datasheet File OCR Text:

AC-DC
165 Watts IFC165 Series
* * * * * * * Small Size - 3.0" x 5.0" x 1.25" High Power Density
xppower.com
Active PFC Meets EN61000-3-2, -3 Single, Dual, Triple & Quad Outputs High Efficiency - up to 90% Overvoltage and Overcurrent Protection Power Fail Detect
Specification
Input
Input Voltage Input Frequency Input Current Inrush Current Power Factor Earth Leakage Current Input Protection * * * * * * * 90-264 VAC 47-63 Hz 2.2 A max at 100 VAC 33 A at 115 VAC, 66 A at 230 VAC 0.90 minimum 0.75 mA max at 240 VAC Internal 3.15 A fuse
General
Efficiency Isolation * 85% typical * 3000 VAC Input to Output 1500 VAC Input to Ground 500 VAC Output to Ground * 86 kHz typical * 8.8 W/In3 * Power Good - On = Logic High AC OK - On = Logic Low (PS12, PS24 & PS48 only) Green LED for AC OK (PS12, PS24 & PS48 only) * 200 kHrs per Bellcore
Switching Frequency Power Density Signals
Output
Output Voltage Output Voltage Trim Initial Set Accuracy Minimum Load Start Up Delay Start Up Rise Time Hold Up Time Line Regulation Load Regulation Over/Undershoot Transient Response Ripple & Noise Overvoltage Protection Overtemperature Protection Overcurrent Protection Short Circuit Protection Temperature Coefficient Remote Sense Current Share * * * * * * * * * * * * * * * * * See table Not user adjustable 5% maximum 5 W minimum load required 1.5 s max at 90 VAC 0.2-20 ms 22 ms min See table and note 1 See table and note 2 <10% at turn on/off 5% max. deviation, recovery to within 1% in 500 s for a 25% load change 1% pk-pk or 50 mV, whichever is greater 113-145% Vnom, recycle input to reset Shuts down at 120C, recycle input to reset 150% max, auto recovery (hiccup mode) Trip and restart (hiccup mode) 0.04% / C MTBF
Environmental
Operating Temperature * -25 C to +70 C, derate linearly from 100% at 50 C to 50% at 70 C Cooling * 12 CFM airflow required for full power Operating Humidity * 85% RH, non-condensing Storage Temperature * -40 C to +85 C Operating Altitude * 3000 m Shock * 15 G pk Vibration * 2.4 G, 5 Hz to 500 Hz, 3 axis
EMC & Safety
Emissions Harmonic Currents Voltage Flicker Radiated Immunity EFT/Burst Surge Dips & Interruptions Safety Approvals * * * * * * * EN55022, level A conducted EN61000-3-2 EN61000-3-3 EN61000-4-3, level 3 Perf Criteria B EN61000-4-4, level 3 Perf Criteria B EN61000-4-5, level 3 Perf Criteria B EN61000-4-11. 30% 10 ms, 60% 100 ms, 100% 5000ms, Criteria A, B, B * EN60950, UL60950, CSA950 per cUL
* Compensates for up to 0.5 V drop * IFC165PSXX models only - up to 4 supplies to share within 10%
1
AC-DC
Models and Ratings
Vnom +5.0 V +12.0 V +24.0 V +48.0 V +5.0 V +3.3 V Notes
1. 2. 3. 4.
IFC165
Output 2 Imax 1.0 A 1.0 A 1.0 A 1.0 A 6.0 A 20.0 A Reg(1) 5% 5% 5% 5% 5% 4% Vnom Output 3 Imax Reg(1) Vnom Output 4 Imax Reg(1) Model Number IFC165PS05 IFC165PS12 IFC165PS24 IFC165PS48 IFC165PT31 IFC165PQ40
Output 1 Imax 33.0 A 13.7 A 6.9 A 3.4 A 21.0 A 16.0 A
Reg(1) 3% 3% 3% 3% 4% 2%
Vnom +12.0 V +12.0 V +12.0 V +12.0 V +12.0 V +5.0 V
-12.0 V +12.0 V
1.0 A 6.0 A
5% 5%
-12.0 V
1.0 A
5%
Total regulation includes tolerance, line regulation and load regulation. 5 W minimum load on any combination of outputs required to maintain regulation. Maximum output power not to exceed 165 W with 12 CFM forced air or 70 W with convection cooling. For IFC165PT31 and PQ40, the maximum output power of Output 1 and 2 combined is 100W with 12CFM of forced air cooling or 40W with convection cooling. With convection cooling, the -12V output can deliver a maximum output of 0.6A.
Mechanical Details
PS12/24/48 Models
5.00 (127.0) 4.55 (115.5) 0.16 (4 places)
Conn Pin 1 J1 2 3 1 2 3 4 5 6 7 8 9 10 11 12 13 14 1 2 3 4 5 6 1 2
PS05 Neutral Line +5 VDC +5 VDC +5 VDC RTN RTN RTN
PS12 Neutral Line +12 V +12 V +12 V RTN RTN RTN
Connector Pinouts PS24 PS48 Neutral Line +24 V +24 V +24 V RTN RTN RTN Neutral Line +48 V +48 V +48 V RTN RTN RTN
PT31 Neutral Line -12 V +12 V N/A N/A N/A RTN RTN RTN RTN RTN +5 V +5 V +5 V +5 V
PQ40 Neutral Line -12 V +12 V +3.3 V +3.3 V +3.3 V RTN RTN RTN RTN RTN +5 V +5 V +5 V +5 V
3.00 (76.2) 2.55 (64.8) J1 Safety ground connection point
J2
TOP
Pin 1
Pin 1 J3 Pin 1 J4 Pin 1
J2
PT31/PQ40 Models
5.00 (127.0) 4.55 (115.5) 0.16 (4 places)
3.00 (76.2) 2.55 (64.8) J1 Safety ground connection point
TOP
J2 Pin 1
J3
Pin 1 Pin 1 J3
J4
N/C AC OK AC OK AC OK PG PG PS OK PG PG PG N/A +3.3 V RS PG CS CS CS -R Sense -R Sense V1 Sense+ +R Sense +R Sense +R Sense 0V Sense- -R Sense -R Sense -R Sense CS RTN RTN RTN +12 V +12 V +12 V +12 V RTN RTN RTN RTN
PS05 Model
5.00 (127.0) 4.55 (115.5) 0.16 (4 places) LED
PS05
J1 Housing Pins Housing Pins Housing Pins Housing Pins
Molex Mating Connectors PS12, 24, 48 PT31, 40
90-50-8033 08-52-0113 09-50-8143 08-52-0113 22-01-3037 08-50-0114 22-01-3027 08-50-0114 09-50-8031 08-52-0113 09-50-8141 08-52-0113 22-01-3037 08-50-0114 N/A N/A
09-50-8031 08-52-0113 Terminal Block N/A 22-01-3037 08-50-0114 22-01-3027 08-50-0114
3.00 (76.2) 2.55 (64.8) J1 Safety ground connection point
TOP
Pin 1 Terminal 1
J2
J2
Pin 1
J4 J3 Pin 1
J3 J4
Hardware shown for reference only - not included 1.00 (25.4) 0.06 (1.52) 0.19 (4.83)
1.25 31.75)
SIDE
The maximum width for the screw head is 0.28 (7.1) #6 or M3 screws recommended. 0.25 inch hex or round stand-offs recommended
END
Notes
1. All dimensions in inches (mm). 2. Weight 0.57 lb (260 g) approx.
27-Jun-05

▲Up To Search▲

Price & Availability of IFC165PQ40

	To Download IFC165PQ40 Datasheet File
If you can't view the Datasheet, Please click here to try to view without PDF Reader .